Circular July 2008
|
3 x 5.2 MW Model #18KU30A Mitsubishi Generator Sets
Three Mitsubishi 5.2MW generator. year 2003 5000kw 6600kva 60Hz Hours: 10,000 - 15,000 each 3 sets
$660,000.00 each As is where is (Complete with Fuel Treatment Module) More pictures on request
|
|
|
30 MW Sulzer Power Plant, 60 Hz
with complete auxiliaries and spare parts.
Please note that the units were installed in early and middle part of 90's..... well maintained.
I. ENGINE:
Make Z.U.T. ZGODA SULZER (Poland)
Model 12 ZV 40/48
Serial numbers 50612
Nominal Power of Diesel Engine 6180 kW (measured at shaft under ISO conditions)
Number of strokes 4 (four)
Cylinder Power 550 kW/cylinder
Number of Cylinders 12
Nominal speed 514 rpm
Maximum power in one hr 7260 kW (during 12 operating hr. each)
Piston Diameter 400 mm
Piston stroke 480 mm
Cylinder capacity 60.82 L/cylinder
Effective pressure 1.99 MPa.
Combustion pressure 12.8 MPa
Average piston speed 8.224 m/s
Flywheel effect (W*R sq.) 4.94 Tm?
Note:
The nominal power of the Engine corresponds to the operating instructions of ISO 3046.
Under the above conditions and assuming a calorific value of 42.707 kJ/kg, the specific fuel
throughput is as follows:
100% load 201 g/kWh + 5%
75% load 201 g/kWh + 5%
50% load 205 g/kWh + 5%
Lube-oil consumption - the consumption in the lube system of the working face of the Cylinders
amounts to 80% of the total consumption
Amount of heat dissipated by the Engine : 290 kW
Combustion air consumption under nominal conditions : 52,500 kg/hr
Air cleaning (by means of NSA filter) : up to 5 g/m3 solids
Mass of Exhaust under nominal conditions : 53,800 kg/hr
Temperature of gasses after turbo compressor under nominal conditions : 340 0C
Noise level at suction and exhaust sides after silencer : 85 dBA
Operating parameters stable minimum speed : 320 rpm
Admissible operating duration at no load : 30 min.
A) Barring Gear (Turning Gear)
B) Turbocharger (Left & Right)
C) Air-cooler (Left & Right)
II. GENERATOR
A) Brushless AC Generator
Make Ideal Electric, (OHIO, USA)
Model Type SAB
Capacity 7500 kVA (6000 kW)
Frame M8-31
Voltage 13,800 V
RPM 514
Amp. 314
Phase / Hz 3 / 60 Hz
Wire 6
Duty Continuous
Power factor 0.8
Class Ins. F
Temp. rise 105 0C
Rise by Res. Amb. temp. 40 0C
B) Brushless Exciter
Type FRBA
Frame BE 16-6
kW output 50
DC volts / Amp. 250 V / 200 A
Class Ins. F
Fld. Volts / Amps. 125 V / 8.8 A
Temp. rise 80 0C
Exciter surge prot. B57826-GR1
Rectifiers qty. 3 no. B-54922-F, no. B-54922-R
C) Permanent Magnet Alternator
III. AIR SYSTEM
1) Suction Air
A) Locker Air-Maze Heavy Duty Oil Bath Air Filter (2 Units)
B) Air Suction BR
C) Expansion Bellows
2) Control Air Equipment
A) Air Bottle
B) Condensate Drain
C) Pressure Reducing Valve
D) Air Dryer
E) Automatic Drain Valve
F) Filter
IV. WATER SYSTEM
1. Raw Water System
A) Cooling Tower
B) Raw Water Pump (Running)
C) Raw Water Pump (Spare)
D) Raw Water Strainer
2. Jacket Water System
A) Jacket Water Heat Exchanger (Alfa Laval)
B) Jacket Water Thermostat (AMOT)
C) Jacket Water Pump (Running) (Ajax Elite)
D) Jacket Water Pump (Spare)
(Ajax Elite)
E) Circulating Pump (Ajax Elite)
F) Jacket Water Expansion Tank
3. Nozzle Cooling Water System
A) Nozzle Cooling Water Pump (Running)
B) Nozzle Cooling Water Pump (Spare)
C) Heater
V. LUBRICATING OIL SYSTEM
A) L.O. Separator Module (LOPX 707)
B) Feed Pump (running)
C) Feed Pump (spare)
D) Pre-Lube Pump
E) Oil Cooler
F) Lube-Oil Filter (Boll and Kirch Auto back-flushing)
G) Indicating Filter (Boll and Kirch)
H) Thermostatic Valve (AMOT 6BO)
I) Cylinder Lube-Oil Tank
J) Lube-Oil Sump Tank
K) Lube-Oil Sludge Tank
L) Lube-Oil Sludge Tank Pump
VI. FUEL OIL SYSTEM
1. Three-way Valve for HFO/MDO
2. Supply Pumps
3. Pressure Control, Overflow Valve
4. Flow Meter
5. Deaeration System
6. Circulating Pumps
7. Steam heat exchanger
8. Electric heat exchanger
9. Viscosity transducer
10. Filter Arrangement
11. Alarm Cabinet
12. Fuel Sludge Tank
13. Fuel Sludge Tank Pump
VII. EXHAUST SYSTEM
A) Silencer (rolled plate)
B) Smoke Stack (rolled plate)
C) Ducting
D) Expansion Bellows
Price 4,340,000.- USD
Best regards
CH Non-Food Import-Export Corporation
Peter Pressmar (CEO)
Skype: peterpressmar
British Virgin Islands
Phone: +1 206-201-2420
Fax: +1 206-337-0754
Phone Brazil: +55 21 3521-7225
mailto:office6@ch-non-food.com
http://www.ch-non-food.com/